Agenda 05/28/2019 Item #16C 5 (PO w/Tradewinds Power Corp)05/28/2019
EXECUTIVE SUMMARY
Recommendation to approve a purchase order with Tradewinds Power Corporation for 16
portable generators in the amount of $941,318 under the Florida Sheriffs Association Cooperative
Purchasing Program Contract # FSA18-VEH16.0 as validated by the Infrastructure Surtax Citizen
Oversight Committee, Project Number 50391, and authorize the necessary budget amendment.
OBJECTIVE: To maintain compliance with local, state and federal regulations and to improve
hurricane resiliency and operational reliability in the wastewater collections system.
CONSIDERATIONS: The Collier County Water-Sewer District (CCWSD) operates approximately 900
wastewater pump stations. Some of these pump stations serve facilities that are critical during an
emergency, some are in environmentally sensitive areas and some are operationally critical based on the
level of service they provide. During a widespread power outage, such as occurred in the wake of
Hurricane Irma, it is essential that critical wastewater pump st ations continue to operate, providing
uninterrupted service to hospitals, shelters, assisted living facilities and emergency services. Equally as
important is the protection of the public health and the environment by ensuring that wastewater stays
within the confines of the collection system. The installation of emergency power at these critical sites
will build resiliency and reliability into some of the most critical areas of the wastewater collection
system. An updated map of infrastructure resiliency for wastewater pump stations is included as
Attachment 1.
The CCWSD identified 32 critical sites that require emergency power. On April 3, 2019 (Agenda Item
8.B.2), the Infrastructure Surtax Citizen Oversight Committee validated the proposed expenditure for
“Hurricane Resilience - Pump Station Emergency Back-up Systems” (See Attachment 2 for Executive
Summary). This project includes 16 portable generators that could be purchased immediately, and 16
permanent generators/diesel pumps that require design, permitting and construction. This item is for the
16 portable generators that can be deployed as soon as they are received. See Attachments 3, 4, and 5 for
Location Map, Proposal, and Approved Piggyback. In addition to the specifications covered under the
FSA contract, the County is requesting each generator to include two wheel chocks and two safety cones
with holder, to secure the generator from theft and to provide general safety. The kilowatt rating
requirements were determined based on the pump station size that each generator is intended to serve.
Other requirements such as components and materials were determined based on historical performance
of current generators.
FISCAL IMPACT: The purchase of 16 portable generators is eligible for Infrastructure Sales Tax
money. On March 6th, 2019, the Citizen Surtax Oversight Committee validated this project in the amount
of $3,500,000 in two phases:
Phase Amount
16 portable generators $1,000,000
16 permanent generators/diesel pumps $2,500,000
Total $3,500,000
At this time, a budget amendment is needed in the amount of $3,500,000 from the Infrastructure Sales
Tax Fund 318 to fund the entire project. Staff will return to the Board for award of a contract for the 16
permanent generators/diesel pumps after that solicitation is complete.
LEGAL CONSIDERATIONS: This item has been reviewed by the County Attorney, raises no legal
16.C.5
Packet Pg. 834
05/28/2019
issues, and requires majority vote for approval. -JAK
GROWTH MANAGEMENT IMPACT: This project meets current Growth Management Plan
standards to ensure the adequacy and availability of viable public facilities and to remain in compliance
with all regulatory programs.
RECOMMENDATION: To approve a purchase order with Tradewinds Power Corporation for 16
portable generators in the amount of $941,318 under the Florida Sheriffs Association Cooperative
Purchasing Program Contract # FSA18-VEH16.0 and authorize the necessary budget amendment.
Prepared by: Tom Chmelik, P.E., Director and Michael Stevens, P.E., Principal Project Mana ger, Public
Utilities Engineering & Project Management Division
ATTACHMENT(S)
1. Attachment 1 - Pump Station Resiliency Map (PDF)
2. Attachment 2 - Approved Surtax Committee Checklist with Executive Summary (PDF)
3. Attachment 3 - Location Map - 32 Critical Pump Stations (PDF)
4. Attachment 4 - Tradewinds Power Corp. Proposal (PDF)
5. Attachment 5 - Approved Cooperative FSA18-VEH16.0 (PDF)
16.C.5
Packet Pg. 835
05/28/2019
COLLIER COUNTY
Board of County Commissioners
Item Number: 16.C.5
Doc ID: 8701
Item Summary: Recommendation to approve a purchase order with Tradewinds Power
Corporation for 16 portable generators in the amount of $941,318 under the Florida Sheriffs Association
Cooperative Purchasing Program Contract # FSA18-VEH16.0 as validated by the Infrastructure Surtax
Citizen Oversight Committee, Project Number 50391, and authorize the necessary budget amendment.
Meeting Date: 05/28/2019
Prepared by:
Title: Division Director - Public Utilities Eng – Public Utilities Planning and Project Management
Name: Tom Chmelik
05/01/2019 4:36 PM
Submitted by:
Title: Division Director - Public Utilities Eng – Public Utilities Planning and Project Management
Name: Tom Chmelik
05/01/2019 4:36 PM
Approved By:
Review:
Wastewater Steve Nagy Additional Reviewer Completed 05/02/2019 5:44 AM
Wastewater Beth Johnssen Additional Reviewer Completed 05/02/2019 9:00 AM
Procurement Services Opal Vann Level 1 Purchasing Gatekeeper Completed 05/02/2019 9:05 AM
Public Utilities Operations Support Joseph Bellone Additional Reviewer Completed 05/02/2019 10:25 AM
Public Utilities Operations Support Tara Castillo Additional Reviewer Completed 05/02/2019 1:27 PM
Public Utilities Planning and Project Management Michael Stevens Additional Reviewer Completed 05/10/2019 10:38 AM
Procurement Services Ted Coyman Additional Reviewer Completed 05/10/2019 5:10 PM
Procurement Services Catherine Bigelow Additional Reviewer Completed 05/11/2019 7:17 AM
Procurement Services Sara Schneeberger Additional Reviewer Completed 05/13/2019 8:26 AM
Public Utilities Department Sarah Hamilton Level 1 Division Reviewer Completed 05/13/2019 11:45 AM
Public Utilities Department George Yilmaz Level 2 Division Administrator Review Completed 05/13/2019 11:57 AM
Office of Management and Budget Valerie Fleming Level 3 OMB Gatekeeper Review Completed 05/13/2019 2:00 PM
County Attorney's Office Jeffrey A. Klatzkow Level 3 County Attorney's Office Review Completed 05/15/2019 1:07 PM
Office of Management and Budget Susan Usher Additional Reviewer Completed 05/17/2019 4:55 PM
County Manager's Office Heather Yilmaz Level 4 County Manager Review Completed 05/20/2019 12:09 PM
Board of County Commissioners MaryJo Brock Meeting Pending 05/28/2019 9:00 AM
16.C.5
Packet Pg. 836
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú[Ú [Ú[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú [Ú
[Ú
[Ú
[Ú
[Ú
[Ú [Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú[Ú
[Ú
[Ú[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú [Ú
[Ú[Ú
[Ú
[Ú[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú
[Ú OLD 41Vanderbilt DR5th AVE S
Green BLVD
Bayshore DRGolden Gate PKWY
9thST SCounty Barn RDW I G G I NSPASS R D
AIRPORT PULLING RD STamiami TRL NDavis BLVDGulf Shore DRBayshore DRGOODLETTE-FRANK RD NThomasson DR9TH ST NCollier BLVDSantaBarbaraBLVDLogan BLVD SRattlesnake Hammock RD WilsonBLVD NWilson BLVD NImmokalee RD
Golden Gate BLV D W
Ta
mia
mi T
R
L E
BluebillAVE
AIRPORT PULLING RD NLIVINGSTON RDLogan BLVD NPine Ridge RD
BONITA BEACH RD
111th AVE N
Vanderbilt Beach RD
Wilson BLVD NRadio RD
Collier BLVDSanta Barbara BLVDTamiami TRL E
O i l W e l l R D
I
7
5I75
Lift Station Ge nerators O Drawn By:
Department:
Date:
Public Utilities Department
Disclaime r: This ma p is a represe nta tion of co mp ile d pub lic informa tion. It is b elieved to be an accu ra te a nd true dep ictio nfor the sta ted pu rp ose, bu t Collie r Co unty an d its e mp lo yees ma ke no gua ra nte es, im plied or oth erwise , as to the accuracyof co mp le ten ess. We the re fore d o n ot accep t a ny re sp on sib ilities a s to its use . This is n ot a survey, nor is itto b e u sed for de sign.0 10.5
Miles
Brian Hartz
PUD-TSLO
3/20/2019
Portable Generators
Legend
MPS Fixed Generators
[Ú 22
Back-Up Diesel Pumps at M PSs
[Ú 4
Fixed Generators at PSs
[Ú 10
Fixed Diesel Pumps at PSs
[Ú 13
Fixed Generators at CPSs (Installed by developers)
[Ú 15
Fixed Generators / Pumps Pursued with FEMA
[Ú 53
Portable Generators
43
Fix ed Ge ne ra tors /Pu mps Pu rs ued w ith ISCOC
Porta ble Gen erators with AT S Pursue d with ISCOC[Ú 16
[Ú 16
16.C.5.a
Packet Pg. 837 Attachment: Attachment 1 - Pump Station Resiliency Map (8701 : 16 Portable Generators - Surtax Funded)
Hurricane Resilience -Pump Station Emergency Back-up Systems 50391
Project Project#
Infrastructure Surtax Citizens Oversite Committee Project Checklist
� Project(s) in line with F.S. 212.055
Expenditure related to infrastructure as follows:
� Construction
� Improvement of public facilities □Land acquisition□Land improvement
� Design
� Engineering costs
� Professional & related costs to bring facility into service (CEI, Material Testing, Specialty
Consultants)
□EMS vehicles associated with 3 new substations
□Court-related expenditures for the construction, lease or maintenance of the Court-related
facilities including utilities and security infrastructure
� Life expectancy of at least 5 years
□Land Acquisition expenditure for Residential housing project where at least 30% of units are
affordable to individuals whose total annual household income does not exceed 120% of area
median income.
� Project(s) in line with County Ordinance 2018-21
� Project(s) identified in Exhibit A within County Ordinance 2018-21
� Project(s) in line with Ballot Language within County Ordinance2018-21
The Infrastructure Surtax Citizens Oversight Co mmittee (ISCOC) validated that the
Hurrica ne Resilience -Pump Station Emergency Back-up Systems project meets the necessary requirements and is
eligible to use Surtax Funding on April � 2019.
Exhibit A Reference
Category: Facilities & Capital Replacements
Sub-Categ ory: Hurricane Resilience
Funding Requested:_$3_.5 _M _______________ _
16.C.5.b
Packet Pg. 838 Attachment: Attachment 2 - Approved Surtax Committee Checklist with Executive Summary (8701 : 16 Portable Generators - Surtax Funded)
EXECUTIVE SUMMARY
Validate the proposed expenditures for the design, purchase and installation of the Hurricane
Resilience - Pump Station Emergency Back-up Systems at thirty-two (32) wastewater pump
stations.
OBJECTIVE: To maintain compliance with local, state, and federal regulations and to improve
hurricane resiliency and operational reliability in the wastewater collection system.
CONSIDERATIONS: The Surtax began to be collected on January 1, 2019. Projects outlined in
County Ordinance 2018-21 are eligible to receive funding from the Surtax so long as the expenditure
occurred after January 1, 2019, the project meets the requirements of F.S. 212.055, conforms to the
definition of Infrastructure, and is in line with County Ordinance 2018-21. There were three main
categories of projects identified in Ordinance 2018-21: Transportation Projects, Facilities & Capital
Replacements and Community Priorities.
The Hurricane Resilience - Pump Station Emergency Back-up Systems project fulfills the definition of
infrastructure as outlined in F.S. 212.055, which defines Infrastructure as:
“Any fixed capital expenditure or fixed capital outlay associated with the construction,
reconstruction, or improvement of public facilities that have a life expectancy of 5 or more years,
any related land acquisition, land improvement, design, and engineering costs, and all other
professional and related costs required to bring the public facilities into service.”
The Collier County Water-Sewer District operates approximately 900 wastewater pump stations. Some
of these pump stations serve facilities that are critical during an emergency, some are in environmentally
sensitive areas, and some are operationally critical based on the level of service they provide. During a
widespread power outage, such as occurred in the wake of Hurricane Irma, it is essential that critical
wastewater pump stations continue to operate to provide uninterrupted service to hospitals, shelters,
assisted living facilities, and emergency services. Equally as important, is the protection of the public
health and the environment by ensuring that wastewater stays within the confines of the collection system.
The installation of emergency back-up systems at these 32 critical sites will build resiliency and reliability
into some of the most critical areas of the wastewater collection system.
FISCAL IMPACT: Exhibit A identified up to $15M for this project; the estimated costs for design,
purchase and installation of emergency power at 32 pump stations is estimated to be $3.5M.
16 Permanent Generators/Pumps $2.5M
16 Portable Generators with ATS $1.0M
LEGAL CONSIDERATIONS: This item has been reviewed by the County Attorney. Ordinance No.
2018-21, the Collier County infrastructure surtax ordinance, created the Infrastructure Surtax Citizen
Oversight Committee, whose duties are as follows:
Duties. The Committee shall have the responsibility to review the expenditure of Surtax
proceeds against the ballot referendum approved by the voters and this Ordinance. The
Board may expend proceeds of the Surtax on projects not specifically stated herein or in
the attached Exhibit A, so long as those projects (1) comply with the intent of the ballot
language, (2) have a positive recommendation by this Committee, and (3) fall within the
16.C.5.b
Packet Pg. 839 Attachment: Attachment 2 - Approved Surtax Committee Checklist with Executive Summary (8701 : 16 Portable Generators - Surtax Funded)
projects and categories identified. The Committee shall not recommend alternative
projects, unless requested by the Board.
A copy of the ordinance, which contains the ballot language, is attached to this Executive Summary
for the Committee’s review. The Committee will note that Hurricane Resilience is specifically included
in Exhibit A.
In addition to the Ordinance, it is important that the Committee be comfortable that the proposed
expenditure comports with Florida Statute Sec. 212.055, which authorizes the local government
infrastructure sales surtax. That statute states, in relevant part as follows:
212.055 Discretionary sales surtaxes; legislative intent; authorization and use of proceeds
(2) LOCAL GOVERNMENT INFRASTRUCTURE SURTAX.
(d) The proceeds of the surtax authorized by this subsection and any accrued interest shall be expended by
the school district, within the county and municipalities within the county, or, in the case of a negotiated
joint county agreement, within another county, to finance, plan, and construct infrastructure; to acquire
any interest in land for public recreation, conservation, or protection of natural resources or to prevent or
satisfy private property rights claims resulting from limitations imposed by the designation of an area of
critical state concern; to provide loans, grants, or rebates to residential or commercial property owners
who make energy efficiency improvements to their residential or commercial property, if a local
government ordinance authorizing such use is approved by referendum; or to finance the closure of
county-owned or municipally owned solid waste landfills that have been closed or are required to be
closed by order of the Department of Environmental Protection. Any use of the proceeds or interest for
purposes of landfill closure before July 1, 1993, is ratified. The proceeds and any interest may not be used
for the operational expenses of infrastructure, except that a county that has a population of fewer than
75,000 and that is required to close a landfill may use the proceeds or interest for long-term maintenance
costs associated with landfill closure. Counties, as defined in s. 125.011
<http://www.leg.state.fl.us/statutes/index.cfm?App_mode=Display_Statute&Search_String=&URL=0100
-0199/0125/Sections/0125.011.html>, and charter counties may, in addition, use the proceeds or interest
to retire or service indebtedness incurred for bonds issued before July 1, 1987, for infrastructure purposes,
and for bonds subsequently issued to refund such bonds. Any use of the proceeds or interest for purposes
of retiring or servicing indebtedness incurred for refunding bonds before July 1, 1999, is ratified.
1. For the purposes of this paragraph, the term “infrastructure” means:
a. Any fixed capital expenditure or fixed capital outlay associated with the construction, reconstruction,
or improvement of public facilities that have a life expectancy of 5 or more years, any related land
acquisition, land improvement, design, and engineering costs, and all other professional and related costs
required to bring the public facilities into service. For purposes of this sub-subparagraph, the term “public
facilities” means facilities as defined in s. 163.3164
<http://www.leg.state.fl.us/statutes/index.cfm?App_mode=Display_Statute&Search_String=&URL=0100
-0199/0163/Sections/0163.3164.html>(39), s.163.3221
<http://www.leg.state.fl.us/statutes/index.cfm?App_mode=Display_Statute&Search_String=&URL=0100
-0199/0163/Sections/0163.3221.html>(13), or s. 189.012
<http://www.leg.state.fl.us/statutes/index.cfm?App_mode=Display_Statute&Search_String=&URL=0100
-0199/0189/Sections/0189.012.html>(5), and includes facilities that are necessary to carry out
governmental purposes, including, but not limited to, fire stations, general governmental office buildings,
and animal shelters, regardless of whether the facilities are owned by the local taxing authority or another
governmental entity.
16.C.5.b
Packet Pg. 840 Attachment: Attachment 2 - Approved Surtax Committee Checklist with Executive Summary (8701 : 16 Portable Generators - Surtax Funded)
A copy of the entire statute is included as back-up to this item.
The County Attorney has reviewed this item and believes that the request meets all the requirements
of both the Statute and the Ordinance. As an aside, only those items which I believe satisfy the
requirements of both the Ordinance and the Statute will be brought to the Committee. My opinion,
however, is not binding on the Committee, as the Board of County Commissioners created this
Committee “to provide for citizen review of the expenditure of the Surtax proceeds by the County… (to)
serve as an ad hoc advisory and reporting body to the County.”
GROWTH MANAGEMENT IMPACT: There are no Growth Management impacts associated with
this action.
RECOMMENDATION: To validate the expenditures for the design, purchase and installation of the
Hurricane Resilience - Pump Station Emergency Back-up Systems; to ensure that this project meets the
requirements of F.S. 212.055, conforms to the definition of Infrastructure, and is an eligible project in line
with County Ordinance 2018-21 and the ballot language within; to make a finding that the project
expenditures are a valid use of Infrastructure Sales Surtax Funding.
Prepared by: Michael Stevens, P.E., Principal Project Manager, Engineering & Project Management
16.C.5.b
Packet Pg. 841 Attachment: Attachment 2 - Approved Surtax Committee Checklist with Executive Summary (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.c
Packet Pg. 842 Attachment: Attachment 3 - Location Map - 32 Critical Pump Stations (8701 : 16 Portable Generators - Surtax Funded)
TO:Collier County - Wastewater Power Systems
6027 Shirley St.Quotation # PSMW041919Q - 45
Naples, Fl. 34109 April 24, 2019
Tel: (239)-776-1709
Attn: Mr. Jason Schulz Sales Rep. Waldron
jason.schulz@colliercountyfl.gov 863-381-2454
We are pleased to offer this Quotation as detailed below
Amount Description Each Extended
7 73,220 512,540
contract No. FSA18-VEH1.0, Spec #077.
7 -25,200 -176,400
Panel will also include a standard "on/off" switch to turn both the ECM and controller off.
12vdc - 6 amp charger mounted internally and wired to battery and outlet.
and special oil drain fittings. Rotate control panel door cover and provide support stay.
Front panel cover will have hex head screws as requested.
and Installed into turn hood of enclosure.
1/8", Marine Grade Aluminum Sound Enclosure modified to have no hole for exhaust,
stainless steel hardware, stainless steel pad-lockable latches, removable doors, and
finished painted a white standard PPG powder coat. Enclosure is rated for an
estimated 72dba at 21'. Oil and water drain lines with brass ball valves
Three position voltage change over switch mounted in the generator can
with one 225amp UL rated generator circuit breaker with a 12vdc shunt trip.
Both the high voltage and low voltage are wired to the rear of the machine to a
separate five (5) point connection boxes clearly identifying voltage connections.
Wet Battery, Battery Rack, and Battery Cables.
Duplex electrical outlet mounted inside in a NEMA 3r box with a Non-GFI Duplex
Electrical Outlet and wired to the external of the enclosure with a
Plug for connection to standard 120vac, 1ph, 20amp service.
Steel Exhaust Flex, Critical Exhaust muffler and rain cap all mounted
Plastic Battery box with lid installed.
Optional Equipment included in above pricing:
277/480 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 67; Load Bank tested.
Perkins Diesel engine, Model 1104D.44TAG2 TIER 3 FLEX @ 1800 RPM complete with
With 12 Volt Electrics, Radiator & Guard
Marathon Brushless Single Bearing Alternator with a PMG and DVR 2000E
Automatic Voltage Regulator & Vibration Isolation Mounts
Basler 2020 NFPA 110 Digital Instrument/Control Panel with Safety Shutdowns
Complete with DC Voltmeter, Hour meter, Oil and Temperature Gauges
Frequency Meter, Ammeter & Voltmeter with Phase Selector Switch, Engine
Cool Down Timer, Remote "E" Stop Contacts, Remote Auto Start Control, Low
Fuel Level Alarm, Breakers for A/C and D/C, and a Emergency Stop Push Button.
45 KW (56 KVA) Standby, 40 KW (50 KVA) Prime Power
Model TP150 Base Awarded Tradewinds Mobile Generator Set under FSA
Deduct for Model TP56-M-FS Mobile Tradewinds Generator Set;
45 KW (56 KVA) Standby, 40 KW (50 KVA) Prime Power
120/208 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 156; Load Bank tested.
45 KW (56 KVA) Standby, 40 KW (50 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 135; Load Bank tested. Hi-Leg on "B" phase
45 KW (45 KVA) Standby, 40 KW (40 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Single Phase, 1.0 Power Factor
Amp Load Capacity: 187; Load Bank tested.
6 0 0 S t. R o a d 6 6 S e b rin g , F lo rid a 3 3 8 7 5
Te l 8 6 3 -3 8 2 -2 1 6 6 FA X 8 6 3 -3 8 2 -1 2 0 6
w w w .tra d e w in d s p o w e r.c o m w w w .p e rk in s p o w e r.c o m
Filters
Pump Sets
Power Units
Generator Sets
Automatic Engine Controls
Page 1
16.C.5.d
Packet Pg. 843 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
5,000lb street legal, single axle trailer with electric brakes, round lunette hitch, chains,
lights, heavy duty fenders, two (2) rear sand shoe jacks and one (1) front jack. Trailer
is specifically design to support this unit and it's special features and will have a
corrosive resistive finish to cover the steel frame with a spare tire.
120 gallon, double wall, inbase fuel tank with a mechanical fuel level gauge and standard
Two (2) separate 0 - 60min, 12vdc timers will be provided for interior and exterior
lighting. Lights on exterior of package will be mounted on each side of enclosure to
illuminate general service area as required. Two lights on inside of package will
illuminate internal general service area.
One complete operation and maintenance manual installed in plastic manual box.
7 T200PLUG-FS - One (1) 200amp Power cord, 50' long hardwired to separate 200amp 4,950 34,650
main breaker with Crouse-Hinds AP20468 connector at end. Note: all voltages will
7 Supply and install two (2) wheel chocks on either side of trailer and affix to trailer with 880 6,160
chains, supply and install two (2) 36" tall safety cones and holder, supply and install
Truck Lite #97960 on front of enclosure, and provide additional 20 feet of 200amp rated
power cord.
53,850 376,950
Additional net adder for 5 year extended warranty.1885 13,193
Multiple unit purchase discount and cost deduct for 45kw machine.-9,280 -64,960
Inc.Inc.
Inc.Inc.
46,455 325,183
Price Validity:
Wire-Transfer:Tradewinds Power Corp Division of Southeast Diesel Corp
F/B/O Wells Fargo Bank
Acct# 4945741023 ABA# 121000248 Michael Waldron
Estimated Shipping date from receipt of order: 18 - 20 Weeks
45 days; 15% Cancellation Charge for Restocking.
Two Thumb screws are provided for remote start stop contacts of Transfer
Onsite Start-up and adjustments. Fuel by others.
Delivery to the Naples, Fl. Curbside
Total
State & Local Tax as Applicable
Full load factory test of complete system
Net cost adder for Collier County specified required features:
Sub Total, FOB our warehouse, Miami, Florida
Switch.
Two Thumb screws are provided for remote alarm indication.
Distribution panel to include Four (4) quad boxes. Two (2) Duplex Receptacle with
GFI and breakers and Two (2) non-GFI Duplex Receptacle with Breakers,
Note all voltages are to be present in each plug. Special cap covers are installed to
prevent injury.
fuel signal that will be read in control panel. Unit will alarm with low fuel and shut down
up critically low fuel. Tank will have lockable fuel cap, drain, and necessary fittings.
Page 2
16.C.5.d
Packet Pg. 844 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
TO:Collier County - Wastewater Power Systems
6027 Shirley St.Quotation # PSMW041919Q - 60
Naples, Fl. 34109 April 24, 2019
Tel: (239)-776-1709
Attn: Mr. Jason Schulz Sales Rep - Waldron
jason.schulz@colliercountyfl.gov 863-381-2454
We are pleased to offer this Quotation as detailed below
Amount Description Each Extended
5 73,220 366,100
contract No. FSA18-VEH16.0, Spec #077.
5 -15,580 -77,900
12vdc - 6amp charger mounted internally and wired to battery and outlet.
and special oil drain fittings. Rotate control panel door cover and provide support stay.
Front panel cover will have hex head screws as requested.
5,000lb street legal, single axle trailer with electric brakes, round lunette hitch, chains,
lights, heavy duty fenders, two (2) rear sand shoe jacks and one (1) front jack. Trailer
is specifically design to support this unit and it's special features and will have a
corrosive resistive finish to cover the steel frame with a spare tire.
120 gallon, double wall, inbase fuel tank with a mechanical fuel level gauge and standard
Two (2) separate 0 - 60min, 12vdc timers will be provided for interior and exterior
lighting. Lights on exterior of package will be mounted on each side of enclosure to
illuminate general service area as required. Two lights on inside of package will
illuminate internal general service area.
One complete operation and maintenance manual installed in plastic manual box.
5 T200PLUG-FS - One (1) 200amp Power cord, 50' long hardwired to separate 200amp 4,950 24,750
main breaker with Crouse-Hinds AP20468 connector at end. Note: all voltages will
5 Supply and install two (2) wheel chocks on either side of trailer and affix to trailer with 880 4,400
chains, supply and install two (2) 36" tall safety cones and holder, supply and install
Truck Lite #97960 on front of enclosure, and provide additional 20 feet of 200amp rated
power cord.
63,470 317,350
Additional net adder for 5 year extended warranty.2221 11,107
Multiple unit purchase discount and cost deduct for 60kw machine.-8,640 -43,200
Inc.Inc.
Inc.Inc.
57,051 285,257
Price Validity:
Wire-Transfer:
Total
45 days; 15% Cancellation Charge for Restocking.
State & Local Tax as Applicable
Estimated Shipping date from receipt of order: 18 - 20 Weeks
Tradewinds Power Corp Division of Southeast Diesel Corp
Full load factory test of complete system
Sub Total, FOB our warehouse, Miami, Florida
Onsite Start-up and adjustments. Fuel by others.
Delivery to the Naples, Fl. Curbside
Net cost adder for Collier County specified required features:
Two Thumb screws are provided for remote alarm indication.
with one 225amp UL rated generator circuit breaker with a 12vdc shunt trip.
Both the high voltage and low voltage are wired to the rear of the machine to a
separate five (5) point connection boxes clearly identifying voltage connections.
Note all voltages are to be present in each plug. Special cap covers are installed to
prevent injury.
fuel signal that will be read in control panel. Unit will alarm with low fuel and shut down
up critically low fuel. Tank will have lockable fuel cap, drain, and necessary fittings.
Distribution panel to include Four (4) quad boxes. Two (2) Duplex Receptacle with
GFI and breakers and Two (2) non-GFI Duplex Receptacle with Breakers,
Two Thumb screws are provided for remote start stop contacts of Transfer
Switch.
Three position voltage change over switch mounted in the generator can
Wet Battery, Battery Rack, and Battery Cables.
Plastic Battery box with lid installed.
Duplex electrical outlet mounted inside in a NEMA 3r box with a Non-GFI Duplex
Electrical Outlet and wired to the external of the enclosure with a
Plug for connection to standard 120vac, 1ph, 20amp service.
Steel Exhaust Flex, Critical Exhaust muffler and rain cap all mounted
and Installed into turn hood of enclosure.
1/8", Marine Grade Aluminum Sound Enclosure modified to have no hole for exhaust,
stainless steel hardware, stainless steel pad-lockable latches, removable doors, and
finished painted a white standard PPG powder coat. Enclosure is rated for an
estimated 72dba at 21'. Oil and water drain lines with brass ball valves
Optional Equipment included in above pricing:
277/480 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 90; Load Bank tested.
Doosan Diesel engine, Model D34 TIER 4 @ 1800 RPM complete with DEF tank,
12 Volt Electrics, Radiator & Guard
Oversized Brushless Single Bearing Alternator with a PMG and BE 2000E
Automatic Voltage Regulator & Vibration Isolation Mounts
Tradewinds NFPA 110 Digital Instrument/Control Panel with Safety Shutdowns
Complete with DC Voltmeter, Hourmeter, Oil and Temperature Gauges
Frequency Meter, Ammeter & Voltmeter with Phase Selector Switch, Engine
Cool Down Timer, Remote "E" Stop Contacts, Remote Auto Start Control, Low
Fuel Level Alarm, Breakers for A/C and D/C, and a Emergency Stop Push Button.
60 KW (75 KVA) Standby, 54 KW (67 KVA) Prime Power
Model TP150 Base Awarded Tradewinds Mobile Generator Set under FSA
Cost deduct for Model T60-M-FS Mobile Power Tradewinds Generator Set;
60 KW (75 KVA) Standby, 54 KW (67 KVA) Prime Power
120/208 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 208; Load Bank tested.
60 KW (75 KVA) Standby, 54 KW (67 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 180; Load Bank tested. Hi-Leg on "B" phase
60 KW (60 KVA) Standby, 54 KW (54 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Single Phase, 1.0 Power Factor
Amp Load Capacity: 250; Load Bank tested.
6 0 0 S t .R o a d 6 6 ···S e b r i n g ,F l o r i d a 3 3 8 7 2
T e l .9 4 1 -3 8 2 -2 1 6 6 ···F a x 9 4 1 -1 2 0 6
16.C.5.d
Packet Pg. 845 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
TO:Collier County - Wastewater Power Systems
6027 Shirley St.Quotation # PSMW041919Q - 100
Naples, Fl. 34109 April 24, 2019
Tel: (239)-776-1709
Attn: Mr. Jason Schulz Sales Rep - Waldron
jason.schulz@colliercountyfl.gov 863-381-2454
We are pleased to offer this Quotation as detailed below
Amount Description Each Extended
2 73,220 146,440
contract No. FSA18-VEH1.0, Spec #077.
2 -19,716 -39,432
Panel will also include a standard "on/off" switch to turn both the ECM and controller off.
120vac, 1ph, Guest Battery Charge with 6 amp, 12vdc output.
of the breaker is prewired to one 5 point connection box clearly identifying
100 KW (125 KVA) Standby, 95 KW (119 KVA) Prime Power
Model TP150 Base Awarded Tradewinds Mobile Generator Set under FSA
Deduct for Model TP100-FS Mobile Tradewinds Generator Set;
100 KW (125 KVA) Standby, 95 KW (119 KVA) Prime Power
120/208 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 346; Load Bank tested.
Automatic Voltage Regulator & Vibration Isolation Mounts
120/240 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 300; Load Bank tested. Hi-Leg on "B" phase
90 KW (90 KVA) Standby, 80 KW (80 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Single Phase, 1.0 Power Factor
Amp Load Capacity: 416; Load Bank tested.
100 KW (125 KVA) Standby, 95 KW (119 KVA) Prime Power
277/480 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 150; Load Bank tested.
Perkins Diesel engine, Model 1204F-E44TTAG2 TIER 4 @ 1800 RPM complete
With 12 Volt Electrics, Radiator & Guard
Marathon Brushless Single Bearing Alternator with a PMG and DVR 2000E
Stainless Steel Exhaust Flex, Critical Exhaust muffler and rain cap all mounted
Basler 2020 NFPA 110 Digital Instrument/Control Panel with Safety Shutdowns
Complete with DC Voltmeter, Hourmeter, Oil and Temperature Gauges
Frequency Meter, Ammeter & Voltmeter with Phase Selector Switch, Engine
Cool Down Timer, Remote "E" Stop Contacts, Remote Auto Start Control, Low
Fuel Level Alarm, Breakers for A/C and D/C, and a Emergency Stop Push Button.
Optional Equipment included in above pricing:
Wet Battery, Battery Rack, and Battery Cables.
Thermostatically Controlled Jacket Water Heater
Duplex electrical outlet mounted inside in a NEMA 3r box with a GFI Duplex
Electrical Outlet and wired to the external of the enclosure with a duplex
Plug for connection to standard 120vac, 1ph, 20amp service.
and Installed into turn hood of enclosure.
1/8", Marine Grade Aluminum Sound Enclosure with vertical discharge air,
stainless steel hardware, Keyed alike and removable doors, and Finished
Painted a white Standard PPG Powder Coat. Enclosure is rated for an
estimated 72dba at 21'. Lock's are 751 and keyed alike.
Three position voltage change over switch mounted in the generator can
with one 400amp UL rated generator circuit breaker. This breaker is equipped
with a 12vdc shunt trip that is driven from the generator control panel to trip on
over load depending upon what position the switch is located in. The load side
6 0 0 S t. R o a d 6 6 S e b rin g , F lo rid a 3 3 8 7 5
Te l 8 6 3 -3 8 2 -2 1 6 6 FA X 8 6 3 -3 8 2 -1 2 0 6
w w w .tra d e w in d s p o w e r.c o m w w w .p e rk in s p o w e r.c o m
Filters
Pump Sets
Power Units
Generator Sets
Automatic Engine Controls
Page 1
16.C.5.d
Packet Pg. 846 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
voltage connection points.
175 gallon, double wall, inbase fuel tank with a mechanical fuel level gauge and
Aluminum storage box mounted at front of trailer to hold a total of 50' of 1/0-4 Type W 2
kv cable hard wired to a 200amp circuit break with all above voltages.
One (1) 50amp, 120/240vac, 1ph receptacle. Each receptacle is protected by
a single breaker located in the load center.
Two (2) separate 0 - 60min, 12vdc timers will be provided for interior and exterior
lighting. Lights on exterior of package will be mounted on each side of enclosure to
illuminate general service area as required. Two lights on inside of package will
illuminate internal general service area and shall be LED.
One complete operation and maintenance manual
2 TIER4-100-FS - Optional equipment - specify - Net cost adder to change engine from 17,845 35,690
current emission certification engine to TIER 4. Range covers 56kwe - 100kwe.
2 T200PLUG-FS - One (1) 200amp Power cord, 50' long hardwired to separate 200amp 4,950 9,900
main breaker with Crouse-Hinds AP20468 connector at end. Note: all voltages will
2 Supply and install two (2) wheel chocks on either side of trailer and affix to trailer with 880 1,760
chains, supply and install two (2) 36" tall safety cones and holder, supply and install
Truck Lite #97960 on front of enclosure, and provide additional 20 feet of 200amp rated
power cord.
77,179 154,358
2 Additional net adder for 5 year extended warranty.2373 4,746
Inc.Inc.
Inc.Inc.
79,552 159,104
Price Validity:
Wire-Transfer:
Running lights, Military type hitch, safety chains, Seven (7) way connector,
Steel, D.O.T. Approved, Dual Torque Spring Axel Street legal Trailer with
Electric Brakes, Fenders, Single Sand Shoe in Front and two in the rear, running
Sub Total, FOB our warehouse, Miami, Florida
standard fuel signal that will be read in control panel. Unit will alarm with leak detection
and low fuel and shutdown on critically low fuel. Tank will have lockable fuel cap, drain,
and necessary fittings with a corrosive resistive final paint covering.
Distribution panel to include two (2) Duplex Receptacle with GFI Trips
and breakers, Two (2) non-GFI Duplex Receptacle with Breakers, One (1)
120vac, 1ph, 30amp, receptacle, 120/240vac, 1ph, 30amp receptacle, and
Two Thumb screws are provided for remote start stop contacts of Transfer
Switch.
Full load factory test of complete system
Optional Equipment not included in above pricing:
Net cost adder for Collier County specified required features:
Tradewinds Power Corp Division of Southeast Diesel Corp
F/B/O Wells Fargo Bank
Acct# 4945741023 ABA# 121000248 Michael Waldron
Onsite Start-up and adjustments. Fuel by others.
Delivery to the Naples, Fl. Curbside
Total
State & Local Tax as Applicable
Estimated Shipping date from receipt of order: 22 - 24 Weeks
45 days; 15% Cancellation Charge for Restocking.
Page 2
16.C.5.d
Packet Pg. 847 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
TO:Collier County - Wastewater Power Systems
6027 Shirley St.Quotation # PSMW041919Q - 150
Naples, Fl. 34109 April 24, 2019
Tel: (239)-776-1709
Attn: Mr. Jason Schulz Sales Rep - Waldron
jason.schulz@colliercountyfl.gov 863-381-2454
We are pleased to offer this Quotation as detailed below
Amount Description Each Extended
2 73,220 146,440
contract No. FSA18-VEH1.0, Spec #077.
Roof mounted, 150 watt solar panel with automatic controller to work in conjunction
with 6amp, 12vdc output - 120vac, 1ph input - Automatic Float Battery Charger
120/240 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Tradewinds NFPA 110 Digital Instrument/Control Panel with Safety Shutdowns
Amp Load Capacity: 451; Load Bank tested.
105 KW (105 KVA) Standby, 95 KW (95 KVA) Prime Power
120/240 Volts [reconnectable], 60 Hz, Single Phase, 1.0 Power Factor
Amp Load Capacity: 437; Load Bank tested.
150 KW (187 KVA) Standby, 135 KW (168 KVA) Prime Power
277/480 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 225; Load Bank tested.
Perkins Diesel engine, Tier 4 @ 1800 RPM complete with
With 12 Volt Electrics, Radiator & Guard
Model TP150 Base Awarded Tradewinds Mobile Generator Set under FSA
150 KW (187 KVA) Standby, 135 KW (168 KVA) Prime Power
120/208 Volts [reconnectable], 60 Hz, Three Phase, 0.8 Power Factor
Amp Load Capacity: 520; Load Bank tested.
150 KW (187 KVA) Standby, 135 KW (168 KVA) Prime Power
Brushless Oversized Single Bearing Alternator with a PMG and DVR 2000E
Automatic Voltage Regulator & Vibration Isolation Mounts
and Installed into turn hood of enclosure.
Complete with DC Voltmeter, Hourmeter, Oil and Temperature Gauges
Frequency Meter, Ammeter & Voltmeter with Phase Selector Switch, Engine
Cool Down Timer, Remote "E" Stop Contacts, Remote Auto Start Control, Low
Fuel Level Alarm, Breakers for A/C and D/C, and an Emergency Stop Push Button.
Optional Equipment included in above pricing:
Wet Battery, Battery Rack, and Battery Cables.
Thermostatically Controlled Jacketed Water Heater
Duplex electrical outlet mounted inside in a NEMA 3r box with a GFI Duplex
Electrical Outlet and wired to the external of the enclosure with a duplex
Plug for connection to standard 120vac, 1ph, 20amp service.
Stainless Steel Exhaust Flex, Critical Exhaust muffler and rain cap all mounted
1/8" Marine Grade Aluminum Sound Enclosure with vertical discharge air,
stainless steel hardware, 4 Keys for the keyed alike and removable doors, and
Finish Painted a white Standard PPG Powder Coat. Enclosure is rated for an
estimated 72dba at 21'.
6 0 0 S t. R o a d 6 6 S e b rin g , F lo rid a 3 3 8 7 5
Te l 8 6 3 -3 8 2 -2 1 6 6 FA X 8 6 3 -3 8 2 -1 2 0 6
w w w .tra d e w in d s p o w e r.c o m w w w .p e rk in s p o w e r.c o m
Filters
Pump Sets
Power Units
Generator Sets
Automatic Engine Controls
Page 1
16.C.5.d
Packet Pg. 848 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
of the breaker is prewired to a 800amp, dual connection box clearly identifying each
phase location and voltage. Box will included but not be limited two (2) camlocks
per phase including neutral and one (1) ground with two (2) compression lugs per
phase including neutral and one (1) ground.
330 gallon inbase fuel tank with a mechanical fuel level gauge and standard fuel
One (1) 50amp, 120/240vac, 1ph receptacle. Each receptacle is protected by
a single breaker located in the load center.
One (1) separate 0 - 60min, 12vdc timers will be provided for exterior
lighting. Lights on exterior of package will be mounted on each side of enclosure to
illuminate general service area as required.
One complete operation and maintenance manual
2 T200PLUG-FS - (1) 200amp Power cord, 50' long hardwired to separate 200amp 4,950 9,900
main breaker with Crouse-Hinds AP20468 connector at end. Note: all voltages will
2 Optional eqpt- specify - Aluminum cover for power connectors. Gas spring lid 3,507 7,014
with snap action limit switch to shut unit off if open, rodent prevention brush,w/ lock.
2 Supply & install two (2) wheel chocks on either side of trailer and affix to trailer with 1,837 3,674
chains, supply and install two (2) 36" tall safety cones and holder, supply and install
Truck Lite #97960, front of enclosure, provides additional 20 feet of 200amp rated
power cord.
83,514 167,028
2 Additional net adder for 5 year extended warranty.2373 4,746
Inc.Inc.
Inc.Inc.
85,887 171,774
Price Validity:
Wire-Transfer:
Net cost adder for Collier County specified required features:
Estimated Shipping date from receipt of order: 22 - 24 Weeks
F/B/O Wells Fargo Bank
signal that will be read in control panel. Unit will alarm with low fuel and shut down
Three position voltage change over switch mounted in the generator can
with one 600amp UL rated generator circuit breaker. This breaker is equipped
with a 12vdc shunt trip that is driven from the generator control panel to trip on
over load depending upon what position the switch is located in. The load side
Steel, D.O.T. Approved, Dual Torque Spring Axle Street legal Trailer with
Electric Brakes, Fenders, Single Sand Shoe in Front and two in the rear,
Running lights, Military type hitch, safety chains, Seven (7) way connector,
Onsite Start-up and adjustments. Fuel by others.
upon critically low fuel, lockable fuel cap, drain, necessary fittings with a corrosive
resistive final paint covering and spare tire.
Distribution panel to include two (2) Duplex Receptacle with GFI Trips
and breakers, Two (2) non-GFI Duplex Receptacle with Breakers, One (1)
120vac, 1ph, 30amp, receptacle, 120/240vac, 1ph, 30amp receptacle, and
Two Thumb screws are provided for remote start stop contacts of Transfer
Switch.
Full load factory test of complete system
Optional Equipment not included in above pricing:
Sub Total, FOB our warehouse, Miami, Florida
Delivery to the Naples, Fl. Curbside
Total
State & Local Tax as Applicable
45 days; 15% Cancellation Charge for Restocking.
Tradewinds Power Corp Division of Southeast Diesel Corp
Page 2
16.C.5.d
Packet Pg. 849 Attachment: Attachment 4 - Tradewinds Power Corp. Proposal (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 850Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 851Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 852Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 853Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 854Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 855Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 856Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 857Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 858Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)
16.C.5.ePacket Pg. 859Attachment: Attachment 5 - Approved Cooperative FSA18-VEH16.0 [Revision 2] (8701 : 16 Portable Generators - Surtax Funded)